Infusing oil with garlic, basil, oregano, or rosemary – The Times and Democrat

Infused oils are only safe for shelf storage when research-based methods are meticulously followed. Added ingredients (garlic and herbs are common) must be acidified before they are added to oils. That does not mean that you cannot infuse oils without acidifying the added ingredients, but failure to acidify will result in a final product that must be stored under refrigeration and used within two or three days.

In 1991, the Food and Drug Administration mandated the addition of an acid to all commercial garlic-in-oil preparations as a safeguard. The proper addition of acid was thought to be virtually impossible to do in a home or restaurant kitchen. However, current research at the University of Idaho has proven a safe method for infusing oils with home acidified garlic, basil, oregano or rosemary.

Why acidify? Clostridium botulinum is the biggest safety concern related to storing jarred and canned foods at room temperatures. That is because the ideal conditions for the botulism toxin to be activated are created in an environment that is low acid, low oxygen, moist, and held at temperatures between 38 °F – 118 °F. Those are exactly the set of conditions that are created when oil is combined with low acid foods (e.g., garlic and herbs). The oil creates a low oxygen environment, garlic and herbs are low acid, there is abundant moisture, and shelf storage temperatures are well within the zone for pathogens to thrive.

There is only one scientifically tested method for infusing oils with garlic and herbs. This researched method was created and tested at the University of Idaho and is specific to fresh garlic, basil, oregano and rosemary. No variations or substitutions have been tested and proven safe.

Again, oils may be infused with fresh herbs or garlic without acidification, but those infusions must be stored in the refrigerator and used within two to three days. And, infused oil (non-acidified) that is left at room temperature for more than two hours must be discarded. Additionally, there are no science-based recommendations for pressure or water-bath canning infused oils.

Top quality and safety requires practicing very best sanitation and personal hygiene during each phase of infusion. This includes washing and drying herbs and/or garlic during prep and using high quality, clean bottles for storage. Dark colored, food grade bottles will help prolong quality storage.

Acidifying involves immersing raw, chopped garlic or fresh herbs in a 3 percent solution of citric acid, soaking for 24 hours and then removing the garlic or herbs from the soaking solution.

Citric acid is the only acid product tested and approved for making oil infusions at home. It is optimal because it contributes fewer flavors than other acids like lemon juice or vinegar. It is often available at health food stores, pharmacies, grocery stores, and retailers that sell canning supplies. Lemon juice and vinegar have not been tested for acidifying garlic and herbs in oil infusions and cannot be substituted for citric acid. And lastly, be careful not to confuse citric acid with ascorbic acid (vitamin C). Ascorbic acid does not have the same acidifying properties as citric acid.

The acidification procedure was developed for garlic, basil, oregano and rosemary. Do not use other vegetables or herbs. To acidify, soak the garlic or herbs in 3% citric acid at room temperature for 24 hours. This is the amount of time required for the acid to fully penetrate the ingredients and bring the acidity beyond the growth limit of the botulism bacteria. Less-concentrated acid solutions or shorter soaking times can result in an unsafe product.

Garlic requires a soaking ratio of one-part garlic to 3 parts of 3 % citric acid solution, by weight.

This is the equivalent to ⅔ cup coarsely chopped, peeled garlic cloves to 2 cups of citric acid solution. Garlic cloves must be peeled and coarsely chopped prior to soaking, with pieces no larger than ¼ inch in any direction to allow complete penetration by citric acid.

Basil, oregano or rosemary require a soaking solution of one-part fresh herb (stems with leaves attached) to 10 parts of 3 % citric acid solution, by weight. This is roughly equivalent to 1½ cups of loosely packed herb to 2 cups of citric acid solution, but it is best to weight out 1.7 ounces (47 grams) of herbs. Weighing the herbs is more accurate than using a volume measure because the density of fresh herbs can vary. During soaking, place a weight on the herbs to keep them submerged in the acid solution for the full 24 hours. When completed drain the citric acid. The garlic, basil, oregano or rosemary is now acidified and safe to add to oil.

Infused oils are safe for shelf storage when using these scientifically tested methods. Dark- colored containers and storage in a cool dark cabinet are optimal. To obtain the longest storage time, store oil infusions in a refrigerator.

For more information on infusing oil, visit the Home & Garden Information Center webpage at http://hgic.clemson.edu and see Fact Sheet #3471.